|
Material
safety data sheet (MSDS)
|
| |
|
1. CHEMICAL
PRODUCT AND COMPANY IDENTIFICATION
|
| Trade
Name |
: |
ALFODET L- 46 |
| Manufacture's
Name Address |
: |
GODREJ
INDUSTRIES LIMITED,
Eastern Express Highway, Vikhroli (East),
Mumbai.
India.
Pin - 400 079. |
| Telephone |
: |
91-22-518
80-10 / 20 / 30 |
| Fax |
: |
91-22-518
80-69 / 96 / 81 |
|
2. COMPOSITION
/ INGREDIENTS (Ref : 1)
|
| Average
Molecular Weight |
: |
324 |
Chemical
Identity
Water
Sodium (C 14) Olefin sulfonate
Sodium sulfate
|
: |
CAS
No.
7732-18-5
68439-57-6
7757-82-6
|
Weight Range
58%
40%
2%
|
| 3.
HAZARD IDENTIFICATION (Ref : 1) |
| Health
Rating |
: |
Slight |
| Flammability
Rating |
: |
Slight |
| Reactivity
Rating |
: |
Slight |
| Contact
Rating |
: |
Slight |
| Storage |
: |
General |
| 4.
FIRST AID MEASURES (Ref : 1) |
| Eye |
: |
Immediately flush eyes with water fro at least 15 minutes, while holding eyelids open.Seek medical attention at once. |
| Skin |
: |
For skin contact flush with large amount of water.If irritation presists,get medical attention Immediately take off all
contaminated clothing. and wash contaminated clothing before reuse. |
| Inhalation |
: |
If symptoms are experienced,remove source of contamination or move victim to fresh air.If the affected person is not breathing ,apply artificial respiration.If breathing is difficult,give oxygen. |
| Ingestion |
: |
If the material is swallowed, get immediate medical attention. |
| *In
all of the above cases, get a doctor to check the affected person. |
| 5.
FIRE HAZARD AND FIRE-FIGHTING MEASURES (Ref : 1) |
| Flash point |
: |
(> 93.9° C) >201° F |
| Means
of extinction |
: |
Use
water spray, Carbon Dioxide, Dry Chemical, or Alcohol Foam. Use Water
to keep fire-exposed container cool. |
| Flammability |
: |
Non-Flammable in solution. |
| Personnel |
: |
Firefighters should wear full protective clothing,including self contained breathing equipment. |
| Hazardous
combustion product |
: |
None |
| 6.
ACCIDENTAL RELEASE (Ref : 1) |
| Engineering Controls |
: |
Ventilation of work sapce. |
| Leak-And-Spill
Procedures |
: |
Ventilate area, sweep up,use protective clothing,store in closed container .store in closed container. Surface will be slippery after spillage. |
| 7.
HANDLING AND STORAGE MEASURES (Ref : 1) |
| Handling
Containers |
: |
Use
full protective gear. Protect containers against physical damage /
direct sunlight / water. |
| Storage
Conditions of Containers |
: |
Use
leak-proof Drums. Store in dry locations, at ambient temperature away from direct sunligh |
| 8.
PERSONAL PROTECTION MEASURES (Ref : 1) |
| Skin |
: |
Rubber
Gloves |
| Respiration |
: |
Air
respirator |
| Eyes |
: |
Goggles |
| Feet |
: |
Safety
Shoes |
| Body |
: |
Lab
Coat |
| Hygiene
precautions |
: |
Remove
contaminated clothing and wash hands between breaks and at the end
of duty hours. |
| 9.
PHYSICAL AND CHEMICAL PROPERTIES (Ref : 1) |
| Physical
state |
: |
Aqueous
Solution |
| Moisture & Volatiles % |
: |
58 |
| Specific
gravity |
: |
1.069 gm /cc |
| Boiling
point |
: |
> 100°
C at 760 mm |
| Pour
point |
: |
25° F |
| Evaporation
Rate |
: |
Estimated slower than Ethyl Ether |
| Vapour Density (Air = 1) |
|
Estimated lighter than Air |
| Solubility
in water (20 C) |
: |
Soluble |
| 10.
REACTIVITY DATA (Ref : 1) |
| Chemical
Stability |
: |
Product
is stable under the prescribed storage conditions. |
| Incompatibility
with other Substances |
: |
Slight reaction with oxidising substances |
| Reactivity and under what conditions |
: |
None |
| Hazardous
Decomposition |
: |
None |
| 11.
TOXICOLOGICAL PROPERTIES (Ref : 1) |
| Toxicity |
: |
Non toxic |
| Skin
contact |
: |
Slight
|
| Inhalation acute
|
: |
None |
| Skin
absorption |
: |
None |
| Inhalation Chronic |
: |
None |
| Eye contact |
|
Slight |
| Ingestion |
: |
mouse
LD 50 > 5.989 gm/kg |
| Effect
of Acute and Chronic Exposure to Material |
: |
The
extensive use of Sodium Alpha Olefin Sulphonate in industry has not been accompanied by
any reports of injury. |
| Irritancy
of material |
: |
Slight |
| Carcinogenicity,Reproductive Effects, Terratogenicity, Mutagenicity |
: |
None
reported |
| 12.
ECOLOGICAL INFORMATION (Ref : 1) |
| The
product should not get into water without treatment. Dissolved
in water, the material is easily biodegradeable (90 %) and
will not cause any disturbance in waste water treatment plants. |
| 13.
WASTE DISPOSAL (Ref : 1) |
| Leak-and-spill
procedures |
: |
Being a liquid it can be collectd,swept up and stored in a closed containers. |
| Disposal |
: |
This material is not hazardous material can be washed off with water jet. |
| 14.
TRANSPORT RECOMMENDATION (Ref : 1) |
| No
special conditions as it is not a regulated product. However, one
should observe the usual precautionary measures for transporting chemicals. |
| 15.
REGULATORY REQUIREMENTS (Ref : 1) |
|
According to the data
available, the product is not regulated product . However, one should
observe prescribed Federal, State and Local measures while dealing
with chemicals.
Listed on EINECS (EU), TSCA (USA), DSL (Canada), AICS (Australia)
and MITI (Japan),Korea & Phillipines.
EINECS No: 270-407-8 JSCI /JCIC :41- 500279
Not listed as a Carcinogen by NTP, IARC or OSHA.
|
| 16.
OTHER INFORMATION |
Sources
of information:
1. Stepan Company-Illinois, USA -MSDS of Bio-Terge AS-40 (Sodium C14Olefin Sulphonate (40 % solution)
|
|
|
DISCLIMER
The
information presented here pertains
only to the product when stored in a sealed condition, as prescribed
above.The information is given in good faith, but no warranty, express
or implied,is made.
|